Product ID:N5146 HI GLOSS GRAY A/D ENAMEL
MSDS Date:01/12/1995
FSC:8010
NIIN:00-598-2634
MSDS Number: BWSSM

NILES CHEMICAL PAINT CO

225 FORT ST
NILES, MI 49120
US

Emergency Phone: 616-683-3377 OR 219-236-5856

Info Phone: 616-683-3377 OR 219-236-5856

Preparer: MIKE LICHATOWICH

Cage: 02388

NILES CHEMICAL PAINT

307 NILES, MI 49120 US

Telephone: 616-683-3377/219-236-5856

Cage: 02388

ALKYD RESIN SOLUTION

Fraction By Weight: 48%

OSHA PEL 100 PPM

ACGIH TLV: 150 PPM;STEL 150 PPM

BUTYL ACETATE (CERCLA) (VAPOR PRESSURE 10 MM HG @ 20C)

CAS: 123-86-4

RTECS: AF7350000

Fraction By Weight: 30%

OSHA PEL 150 PPM

ACGIH TLV: 150 PPM;STEL 200 PPM

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

BARIUM SULFATE

CAS: 7727-43-7

RTECS: CR0600000

Fraction By Weight: 8%

ORGANOPHILIC CLAY

CAS: 1335-30-4

Fraction By Weight: <1%

COBALT COMPOUNDS (AS CO) (SARA 313)

CAS: 7440-48-4

RTECS: GF8750000

Fraction By Weight: <1%

OSHA PEL 0.1 MG/M3

ACGIH TLV: 2 MG/M3

PROPRIETARY INGREDIENTS (MFR STATES NOT HAZARDOUS UNDER

Fraction By Weight: BALANCE

Routes of Entry: Inhalation:UNKNOWN Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:EYE:SEVERE IRRITATION, TEARING,
REDNESS, BLURRED VISION. SKIN:REDNESS & IRRIT, DEFATTING LEADING TO
DERMATITIS. INHAL:NASAL & RESPIRATORY IRRIT, CNS DEPRESSION
(DIZZINESS,DROWSINESS,WEAKNESS,FATIGUE,C ONFUSION)
NAUSEA,HEADACHE,VERTIGO,UNCONSCIOUSNESS,ASPHYXIATION. INGEST:GI
IRRIT,ABDOMINAL PAIN,NAUSEA,VOMITING,DIARRHEA.
Effects of Overexposure:CHRONIC: DERMATITIS, PROLONGED EXPOSURE TO
SOLVENTS MAY CAUSE CHRONIC HEALTH EFFECTS.

TARGET ORGANS: LI VER, KIDNEYS, EYES, SKIN, RESPIRATORY SYSTEM,
CNS.
Medical Cond Aggravated by Exposure:NONE KNOWN

First Aid:INHALATION: MOVE TO FRESH AIR IMMED. IF BREATHING
STOPPED,GIVE ARTIFICIAL RESPIRATION. GET MEDICAL AID AS SOON AS
POSSIBLE. SKIN: WASH W/SOAP & WATER. EYE: IMMEDIATELY FLUSH W/LARGE
AMOUNT WATER AT LE AST 15 MINUTES, LIFTING EYELIDS. GET MEDICAL AID
IMMED. DON'T WEAR CONTACT LENSES. INGEST: DRINK 1-2 GLASSES WATER.
DON'T INDUCE VOMITING. CONSULT DR/POISON CONTROL CTR IMMED. TREAT
SYMPTOMATICALLY.

Flash Point Method:TCC
Flash Point:72.0F,22.2C
Lower Limits:0.8
Upper Limits:7.6
Extinguishing Media:DRY CHEMICAL, FOAM, CO2
Fire Fighting Procedures:WEAR SCBA W/FULL FACPIECE (POSITIVE PRESSURE
MODE) & FULL PROTECT CLOTH. USE WATER TO COOL CLOSED CNTNR TO
PREVENT PRESSURE BLDUP/AUTO IGNIT/EXPLOSION W/HEAT.
Unusual Fire/Explosion Hazard:KEEP CNTNR CLSD. KEEP FROM HEAT/IGNIT
SOURCE. CLSD CNTNR MAY EXPLODE W/HEAT. APPLIC TO HOT SURFACE REQ
SPECIAL PRECAUTION. OVEREXPOSURE TO DECOMP PROD-HLTH HZD.

Spill Release Procedures:ELIM IGNIT SOURCE.MINIMIZE BREATHING OF
VAPOR.AVOID SKIN CONTACT.ABSORB W/INERT MAT'L (CLAY,SOIL,COMMERCIAL
ABSORBNT).SMALL:SHOVEL RECLAIMED LIQ & ABSORB INTO RECOVERY/SALVAGE
DRUMS FOR DISPOSAL.LRG:D IKE.RECLAIM INTO RECOVERY/SALVAGE
DRUMS,TANK TRUCK

Handling and Storage Precautions:AVOID STORAGE IN HIGH TEMPERATURES
AREAS OR NEAR FIRE OR OPEN FLAME. KEEP CONTAINERS CLOSED WHEN NOT
IN USE. AVOID ROUGH HANDLING.
Other Precautions:CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN
EMPTY. DO NOT WELD OR FLAME CUT ON EMPTY DRUMS. SHOCK FROM DROPPING
MAY SPLIT CONTAINER.

Respiratory Protection:WEAR (TYPE TC-23C-75) PROPERLY FITTED HALF MASK
OR FULL FACEPIECE RESPIRATOR (NIOSH/MSHA) DURING & AFTER
APPLICATION UNLESS MONITORING DEMONSTRATES CONTAMINANT LEVELS BELOW
APPLICABLE LIMITS. FOLLOW R ESPIRATOR MFR'S DIRECTIONS FOR USE.
Ventilation:KEEP CONTAMINANT BELOW PEL/TLV. REMOVE DECOMP PRODUCT
FORMED DURING WELD/FLAME CUT/ETC. VENT VAPOR FROM BAKING FINISHES.
Protective Gloves:NITRILE OR VITON (CHEM RESISTANT) GLOVES
Eye Protection:CHEM GOGGLES,SAFETY GLASSES,FACE SHIELD
Other Protective Equipment:WEAR CHEMICAL RESISTANT (NITRILE OR VITON)
CLOTHING AS NEEDED TO PREVENT SKIN CONTACT.
Work Hygienic Practices:WASH PROMPTLY WHEN SKIN BECOMES CONTAMINATED.
WASH HANDS BEFORE EATING, SMOKING OR USING RESTROOM.
Supplemental Safety and Health
REMOVE ANY CLOTHING THAT BECOMES WET (TO AVOID FLAMMABILITY HAZARD) AND
WASH BEFORE REUSE.

HCC:F2
Boiling Pt:B.P. Text:212 TO 398F
Vapor Density:> AIR
Spec Gravity:1.137
VOC Grams/Liter:3.07
Viscosity:70 - 80 KU
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:YES
Appearance and Odor:LIQUID, ODOR OF SOLVENTS
Percent Volatiles by Volume:41.94
Corrosion Rate:MINIMAL

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZERS, NITRATES, ALKALIES, ACIDS
Stability Condition to Avoid:HIGH TEMPERATURES
Hazardous Decomposition Products:CAN PRODUCE CARBON MONOXIDE AND OR
CARBON DIOXIDE
Conditions to Avoid Polymerization:HIGH TEMPERATURES

Waste Disposal Methods:DISPOSE OF IN ACCORDANCE WITH APPLICABLE LOCAL,
STATE, AND FEDERAL REGULATIONS. EPA HAZARDOUS WASTE CODE: D001
(IGNITABLE).

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.